Sound-absorbing properties of porous glass ceramics from zeolite-containing rocks
https://doi.org/10.22227/1997-0935.2024.9.1521-1529
Abstract
Introduction. Sound-absorbing systems are widely used in construction, reconstruction, repair of industrial and civil facilities, as well as in mechanical engineering. The most affordable and widely used systems are those using porous materials. The influence of the type, size, nature of pores, as well as phase composition of porous glass-ceramic samples obtained from zeolite-containing rocks on its sound-absorbing properties was established.
Materials and methods. The results of experimental studies were obtained by the impedance method, as well as by methods of X-ray phase analysis, light microscopy, X-ray microtomography, etc.
Results. Porous glass-ceramic materials with average density grades D250 and D300, compressive strength class B3.5, thermal conductivity coefficient from 0.066 to 0.079 W/m∙°C and recommended maximum application temperature up to +850 °C were investigated. The total porosity of the tested specimens of glass-ceramic materials was from 87.7 to 90.1 %, and the number of open pores from to 18.3 %. The sound-absorbing properties of porous glass-ceramic specimens are directly dependent on the open porosity of the material. With an increase of this indicator from 4.5 to 18.3 %, the sound absorption coefficient of the material increased 1.5–2 times, depending on the range of sound frequencies.
Conclusions. Porous glass ceramics obtained from zeolite-containing rocks have good physical and mechanical properties and a high application temperature (at least +850 °C), and with a high open porosity index, it can be recommended for application as sound-absorbing materials in construction and mechanical engineering facilities.
Keywords
porous glass ceramics,
sound-absorbing properties,
sound absorption coefficient,
impedance pipe,
X-ray phase analysis,
X-ray microtomography,
zeolite-containing rocks
Supporting agencies: The work was carried out within the framework of a grant from the Russian Science Foundation (project No. 21-79-10422).
About the Authors
A. A. Ermakov
National Research Ogarev Mordovia State University (MRSU)
Russian Federation
Russian Federation
Anatoly A. Ermakov — postgraduate student of the Department of Building Materials and Technologies
68 Bolshevistskaya st., Saransk, 430005
Scopus: 57255879600, ResearcherID: AAH-5492-2021
A. I. Safin
Samara National Research University (Samara University)
Russian Federation
Russian Federation
Artur I. Safin — Candidate of Technical Sciences, Associate Professor, Associate Professor of the Department of Automatic Systems of Power Plants
34 Moskovskoe shosse, Samara, 443086
Scopus: 55651858200, ResearcherID: R-1785-2017
A. I. Rodin
National Research Ogarev Mordovia State University (MRSU)
Russian Federation
Russian Federation
Aleksander I. Rodin — Candidate of Technical Sciences, Associate Professor, Associate Professor of the Department of Building Materials and Technologies;
68 Bolshevistskaya st., Saransk, 430005
Scopus: 57191249816, ResearcherID: M-9822-2017
References
1. Gerasimov A.I. Sound-insulating and sound-absorbing materials and their application in construction. Academia. Architecture and Construction. 2009; 5:209-215. EDN MTPDKF. (rus.).
2. Radoutsky V.Yu., Stepanova М.N., Shulzhe-nko V.N. Modern sound-absorbing materials and structures. Bulletin of BSTU named after V.G. Shukhov. 2016; 6:76-79. EDN VWZDJJ. (rus.).
3. Shashkeev K.A., Shuldeshov E.M., Popkov O.V., Kraev I.D., Yurkov G.Yu. Porous sound-absorbing materials : review. Proceedings of VIAM. 2016; 6(42):6. DOI: 10.18577/2307-6046-2016-0-6-6-6. EDN WBFNJT. (rus.).
4. Arenas J.P., Crocker M.J. Recent trends in porous sound-absorbing materials. Sound & Vibration. 2010; 44(7):12-17.
5. Yang T., Hu L., Xiong X., Petrů M., Noman M.T., Mishra R., Militký J. Sound absorption properties of natural fibers : a review. Sustainability. 2020; 12(20):8477. DOI: 10.3390/su12208477
6. Yang M., Sheng P. Sound absorption structures: from porous media to acoustic metamaterials. Annual Review of Materials Research. 2017; 47(1):83-114. DOI: 10.1146/annurev-matsci-070616-124032
7. Khosrozadeh A., Rasuli R., Hamzeloopak H., Abedini Y. Wettability and sound absorption of graphene oxide doped polymer hydrogel. Scientific Reports. 2021; 11(1). DOI: 10.1038/s41598-021-95641-z
8. Li T.T., Chuang Y.C., Huang C.H., Lou C.W., Lin J.H. Applying vermiculite and perlite fillers to sound-absorbing/thermal-insulating resilient PU foam composites. Fibers and Polymers. 2015; 16(3):691-698. DOI: 10.1007/s12221-015-0691-8
9. Fediuk R., Amran M., Vatin N., Vasilev Y., Lesovik V., Ozbakkaloglu T. Acoustic properties of innovative concretes : a review. Materials. 2021; 14(2):398. DOI: 10.3390/ma14020398
10. Li Z., Yang Ch., Yan K., Xia M., Yan Z., Wang D. et al. Rational design of a polypropylene composite foam with open-cell structure via graphite conductive network for sound absorption. Soft Matter. 2024; 20(5):1089-1099. DOI: 10.1039/d3sm01432k
11. Zhang X., Chen X., Min W., Liang G., Zhang W., Yao Sh. et al. Preparation of multifunctional ceramic foams for sound absorption, waterproofing, and antibacterial applications. RSC Advances. 2024; 14(2):1009-1017. DOI: 10.1039/D3RA06675D
12. Bessonov I.V., Bulgakov B.I., Aleksandro-va O.V., Gorbunova E.A. Performance evaluation of foamed materials based on cold-cured liquid glass. Nanotechnologies in Construction : a Scientific Internet-Journal. 2023; 15(5):424-437. DOI: 10.15828/2075-8545- 2023-15-5-424-437. EDN WMFMFZ. (rus.).
13. Fedosov S.V., Bakanov M.O., Grushko I.S. Using anthropogenic raw materials in the process of sy-nthesizing foam glass with heterogeneous microstructure. Vestnik MGSU [Monthly Journal on Construction and Architecture]. 2024; 19(2):258-269. DOI: 10.22227/1997-0935.2024.2.258-269. EDN HISRSO. (rus.).
14. Beregovoi V.A., Sorokin D.S., Beregovoi A.M. Glass-crystalline materials of a cellular structure, formed by vibration foaming technology. Defect and Diffusion Forum. 2021; 410:823-828. DOI: 10.4028/www.scientific.net/DDF.410.823
15. Hisham N.A.N., Zaid M.H.M., Aziz S.H.A., Muhammad F.D. Comparison of foam glass-ceramics with different composition derived from ark clamshell (ACS) and soda lime silica (SLS) glass bottles sintered at various temperatures. Materials. 2021; 14(3):570. DOI: 10.3390/ma14030570
16. Ivanov K.S. Associated synthesis of microgranular foam-glass-ceramic from diatomaceous shales. Glass and Ceramics. 2022; 79(5-6):234-238. DOI: 10.1007/s10717-022-00491-4
17. Liu Sh., Chen W., Zhang Y. Design optimization of porous fibrous materials for maximizing absorption of sound under set frequency bands. Applied Acoustics. 2014; 76:319-328. DOI: 10.1016/j.apacoust.2013.08.014
18. Rodin A.I., Ermakov A.A., Erofeeva I.V., Erofeev V.T. Structure and properties of porous glass ceramics from siliceous rocks with the addition of Mg(OH)2. Materials Physics and Mechanics. 2023; 51(5):127-141. DOI: 10.18149/MPM.5152023_13. EDN CAAATB.
19. Rodin A., Ermakov A., Kyashkin V., Rodina N., Erofeev V. Processes of foaming and formation of the structure of porous glass ceramics from siliceous rocks. Magazine of Civil Engineering. 2023; 5(121):125-135. DOI: 10.34910/MCE.121.9. EDN ERASHS.
20. Kuznetsov A.V., Igolkin A.A., Safin A.I., Pantyushin A.O. Mathematical model of acoustic characteristics of polyurethane foam used for sound absorption in aerospace engineering. Vestnik of Samara University. Aerospace and Mechanical Engineering. 2021; 20(2):53-62. DOI: 10.18287/2541-7533-2021-20-2-53-62. EDN FQVVBD. (rus.).
21. Kahlenberg V., Girtler D., Arroyabe E., Kaindl R., Többens D.M. Devitrite (Na2Ca3Si6O16) — structural, spectroscopic and computational investigations on a crystalline impurity phase in industrial soda-lime glasses. Mineralogy and Petrology. 2010; 100(1-2):1-9. DOI: 10.1007/s00710-010-0116-8
Review
For citations:
Ermakov A.A., Safin A.I., Rodin A.I. Sound-absorbing properties of porous glass ceramics from zeolite-containing rocks. Vestnik MGSU. 2024;19(9):1521-1529. (In Russ.) https://doi.org/10.22227/1997-0935.2024.9.1521-1529
Views:
154
Email this article 